* Inspecting the Well
* Shutting and diverting the well
* Lining up the new Well
* Flushing the Well
* Collection of the Well Data
* Cleaning and greasing of Well
WELL PLATFORM OPERATION
› Gathering the Produced fluid from well
› Testing of Liquid and gas flow rate of individual well after seperation
› Transfering of well fluids to process platform through subsea flow line
› Instrument Gas Always Stored in Volume Bottle For Startup
› Wells are controlled through well head control panel.
WELL CUM PROCESS PLATFORM OPERATION
ò Seperation of Gas, Oil and water
ò Treating and pumping oil to subsea offtake pipeline
ò Treating and compressing gas to subsea off pipeline
ò Conditioning associated gas for fuel
ò Disposal of excess gas by flaring
ò Generation of Power
ò Potable water production.
WATER INJECTION OPERATION
iTesting of Injection water
iLifting of Sea water
iFiltration of Injection water
iDeoxygenation of injection water
iMaintenance of injection water
iPumping the treated water to injection well
iPattern of injection
iInjection water treatment
# Selecting the suitable pig.
# Lining of the launcher
# Lining of the receiver
# Collecting the samples for analysis.
OIL AND GAS SAMPLE COLLECTING OPERATION
? Checking wind direction
? Connecting tube from P/H
? Draining the crude for flushing
? Cleaning sample container thoroughly with crude
? Collection of sample and keeping sample container open to remove vapour.
? Attaching the detail about sample.
OPERATION OF GAS DEHYDRATION
/ Seperating gas, condensate and water
/ Coalescing of gas
/ Absorbing the water vapour
/ Scrubbing off dry gas
/ Seperation of glycol, oil and gas
/ Removal of water from glycol
/ Filtration of glycol
/ Recirculation of glycol
OPERATION OF CRUDE STABILIZATION
" Primary seperating operation.
" Secondary seperating operation.
" Tertiary seperating operation
" Storage of oil
" Disposal of formation water
" Timely checking of water and oil level in the seperation section.
WELL TESTING OPERATION OF GGS
^ Check the well and header
^ Lineup the test seperator
^ Fitting proper size orifice
^ Record the gas, oil and water flow rate every hour
^ Check oil and water level
^ After testing depressurize the seperator
^ After testing divert T/H to P/H
^ Cleaning the skid.
CONTROL AND COMMUNICATION OPERATION
P Panels/Equipment for direct and multiplexed control operation.
P Control and Data acquisition signal carrier
P Power fluid carrier pipe.
P Power fluid pipe and panel
P Life boat radio, VHF-FM, VHF-F and VHF-AM
P RTU-combination with RPMC assist operation of well platform from CCR and
data about equipment.
OPERATION OF N2 PRODUCTION
a Sucking the atmosphere air
a Compressing the air
a Removing moisture in the air
a Absorption of N2 from compressed air
a Regenerating of the absorber
a filtration of N2 gas
a Recording the N2 gas flow rate.
THE EFFLUENT TREATMENT OPERATION
E Collecting all the process waste
E Equalisation of the waste stream
E Seperating the free oil
E Chemical treatment for removal of emulsified oil and SS
E Biological treatment for removal of BOD and COD
E Tertiary treatment for removal of SS and COD.
CRUDE LOADING OPERATION
/ Draining of the S/T
/ Checking the tank level
/ Check the tanker's proper condition
/ Arranging the safety & Fire equipment
/ Properly earth the tanker & disconnect the battery terminal
/ Start the oil Pump.
/ After loading stop the pump & check the gas connection in the area
We are doing fire drill every week. Gas detector was fitted in all the vessels. Fire detector was fitted in all places. Keeping the fire extinguisher in all places. We are using water sprinkler system also. We are using the hand gloves, safety belt, helmet and shoes. We are using all type of Extinguishers Co-2-, Foam DCP and sand bucket.
2. Work Experience - CV/Resume Part 2 [Mandatory]
1, (Classic Engineering Bombay High Offshore Protection Operator
Contractors with (Jan2004 - Feb2005)
Oil and Natural Gas Corporation)
2, (Thakkans Nakco Bombay High Offshore Protection Operator
Contractors with (Mar2005 - Nov2007)
Oil and Natural Gas Corporation)
3. Education & Training - CV/Resume Part 3 [Mandatory]
1. S.S.L.C M.S.P.S.Hr.Sec. School Mallanginar. 1998-1999 54%
2. I.T.I [MMV] Sri Jayavilas Subburaj
Memorial Industrial Training Centre, Aruppukottai. 1999-2001 79%
4. Computer Skills - CV/Resume Part 4 [Mandatory]
Packages : MS Office
Operating System : Windows XP/98/2000
5. Other Skills - CV/Resume Part 5 [Optional]
6. Additional Information - CV/Resume Part 6 [Optional]
F.P.F.F. completed from YAK in Mumbai
P.S.T. completed from YAK in Mumbai
P.S.S.R. completed from YAK in Mumbai
E.F.A. completed from YAK in Mumbai
H.U.E.T. completed from YAK in Mumbai